U6046B-MY

U6046B-MY Datasheet

The bi-polar long-term timer U6046B is designed to automatically limit the operation time of high loads in the harsh automotive environment with a preset delay time. With the power-on-reset function the timers guarantee that current consuming devices are not operated unintentionally.

Part	Datasheet
U6046B-MY	U6046B-MY (pdf)

Related Parts	Information
U6046B-MFPG3Y	U6046B-MFPG3Y
U6046B-MFPY	U6046B-MFPY

PDF Datasheet Preview
• Delay Time Range 3.7s to 20h • RC Oscillator Determines Timing Characteristics • Relay Driver with Z-diode • Debounced Input for Toggle Switch • Two Debounced Inputs ON and OFF • Load-dump Protection • RF Interference Protected • Protection According to ISO/TR7637-1 VDE 0839 • Inputs Switched to VBatt The bi-polar long-term timer U6046B is designed to automatically limit the operation time of high loads in the harsh automotive environment with a preset delay time. With the power-on-reset function the timers guarantee that current consuming devices are not operated unintentionally. The delay time can be interrupted manually, but a retrigger function is not provided. Figure Block Diagram with External Circuit OSC 6 -Vstab 7 47 µF + C1 R1 -VS 8 510Ω Oscillator Stabilization Power-on reset Load dump detection 1 GND VBatt Rear Window Heating Timer/ Long-term Timer U6046B 4 OFF 5 TOGGLE Frequency divider Debouncing Mono flop Relay control 2 output Pin Configuration Figure Pinning GND 1 OUT 2 ON 3 OFF 4 8 VS 7 VSTAB 6 OSC 5 TOGGLE Table Pin Description Pin 1 2 3 4 5 6 7 8 Symbol GND OUT ON OFF TOGGLE OSC VSTAB VS Function Reference point, ground Relay control output Switch-on input Switch-off input Toggle input RC-oscillator input Stabilized voltage Supply voltage 2 U6046B U6046B Functional Description Power Supply Pin 8 For reasons of interference protection and surge immunity, the supply voltage pin 8 must be provided with an RC circuit as shown in Figure Dropper resistor, R1, limits the current in case of overvoltage, whereas C1 smooths the supply voltage at pin Recommended values are R1 = 510Ω, C1 = 47 µF. The integrated Z-diode 14V protects the supply voltage, VS. Therefore, the operation of the IC is possible between 6V and 16V, supplied by VBatt. However, it is possible to operate the integrated circuit with a 5V supply, but it should be free of interference voltages. In this case, pin 7 is connected to pin 8 as shown in Figure 3-2 on page 3, and the R1C1 circuit is omitted. Ordering Information Extended Type Number U6046B-MY U6046B-MFPY U6046B-MFPG3Y Package Information Package DIP8 SO8 Package DIP8 Dimensions in mm max. Remarks Pb-free Tubed, Pb-free Taped and reeled, Pb-free U6046B nom. B 3 x = nom. max. Drawing-No. Issue 1; technical drawings according to DIN specifications Package SO 8 Dimensions in mm Drawing-No. Issue 1; technical drawings according to DIN specifications 14 U6046B U6046B History 4674B-AUTO-09/05 • Put datasheet in a new template • Pb-free Logo on page 1 added • Heading Rows on Table “Absolute Maximum Ratings” on page 9 added • Table “Ordering Information” on page 14 changed Atmel Corporation 2325 Orchard Parkway San Jose, CA 95131, USA Tel 1 408 441-0311 Fax 1 408 487-2600 Regional Headquarters Europe Atmel Sarl Route des Arsenaux 41 Case Postale 80 CH-1705 Fribourg Switzerland Tel 41 26-426-5555 Fax 41 26-426-5500 Asia Room 1219 Chinachem Golden Plaza 77 Mody Road Tsimshatsui East Kowloon Hong Kong Tel 852 2721-9778 Fax 852 2722-1369 Japan 9F, Tonetsu Shinkawa Bldg. 1-24-8 Shinkawa Chuo-ku, Tokyo 104-0033 Japan Tel 81 3-3523-3551 Fax 81 3-3523-7581 Atmel Operations Memory 2325 Orchard Parkway San Jose, CA 95131, USA Tel 1 408 441-0311 Fax 1 408 436-4314 Microcontrollers 2325 Orchard Parkway San Jose, CA 95131, USA Tel 1 408 441-0311 Fax 1 408 436-4314 La Chantrerie BP 70602 44306 Nantes Cedex 3, France Tel 33 2-40-18-18-18 Fax 33 2-40-18-19-60 ASIC/ASSP/Smart Cards Zone Industrielle 13106 Rousset Cedex, France Tel 33 4-42-53-60-00 Fax 33 4-42-53-60-01 1150 East Cheyenne Mtn. Blvd. Colorado Springs, CO 80906, USA Tel 1 719 576-3300 Fax 1 719 540-1759 Scottish Enterprise Technology Park Maxwell Building East Kilbride G75 0QR, Scotland Tel 44 1355-803-000 Fax 44 1355-242-743 RF/Automotive Theresienstrasse 2 Postfach 3535 74025 Heilbronn, Germany Tel 49 71-31-67-0 Fax 49 71-31-67-2340 1150 East Cheyenne Mtn. Blvd. Colorado Springs, CO 80906, USA Tel 1 719 576-3300 Fax 1 719 540-1759 Biometrics/Imaging/Hi-Rel MPU/ High Speed Converters/RF Datacom Avenue de Rochepleine BP 123 38521 Saint-Egreve Cedex, France Tel 33 4-76-58-30-00 Fax 33 4-76-58-34-80 Literature Requests Disclaimer The information in this document is provided in connection with Atmel products. No license, express or implied, by estoppel or otherwise, to any intellectual property right is granted by this document or in connection with the sale of Atmel products. EXCEPT AS SET FORTH IN ATMEL’S TERMS AND CONDITIONS OF SALE LOCATED ON ATMEL’S WEB SITE, ATMEL ASSUMES NO LIABILITY WHATSOEVER AND DISCLAIMS ANY EXPRESS, IMPLIED OR STATUTORY WARRANTY RELATING TO ITS PRODUCTS INCLUDING, BUT NOT LIMITED TO, THE IMPLIED WARRANTY OF MERCHANTABILITY, FITNESS FOR A PARTICULAR PURPOSE, OR NON-INFRINGEMENT. IN NO EVENT SHALL ATMEL BE LIABLE FOR ANY DIRECT, INDIRECT, CONSEQUENTIAL, PUNITIVE, SPECIAL OR INCIDENTAL DAMAGES INCLUDING, WITHOUT LIMITATION, DAMAGES FOR LOSS OF PROFITS, BUSINESS INTERRUPTION, OR LOSS OF INFORMATION ARISING OUT OF THE USE OR INABILITY TO USE THIS DOCUMENT, EVEN IF ATMEL HAS BEEN ADVISED OF THE POSSIBILITY OF SUCH DAMAGES. Atmel makes no representations or warranties with respect to the accuracy or completeness of the contents of this document and reserves the right to make changes to specifications and product descriptions at any time without notice. Atmel does not make any commitment to update the information contained herein. Unless specifically provided otherwise, Atmel products are not suitable for, and shall not be used in, automotive applications. Atmel’s products are not intended, authorized, or warranted for use as components in applications intended to support or sustain life. Atmel Corporation All rights reserved. logo and combinations thereof, Everywhere You and others, are registered trademarks or trademarks of Atmel Corporation or its subsidiaries. Other terms and product names may be trademarks of others. Printed on recycled paper.

PDF Datasheet Preview

• Delay Time Range 3.7s to 20h
• RC Oscillator Determines Timing Characteristics
• Relay Driver with Z-diode
• Debounced Input for Toggle Switch
• Two Debounced Inputs ON and OFF
• Load-dump Protection
• RF Interference Protected
• Protection According to ISO/TR7637-1 VDE 0839
• Inputs Switched to VBatt

The bi-polar long-term timer U6046B is designed to automatically limit the operation time of high loads in the harsh automotive environment with a preset delay time. With the power-on-reset function the timers guarantee that current consuming devices are not operated unintentionally.

The delay time can be interrupted manually, but a retrigger function is not provided.

Figure Block Diagram with External Circuit

OSC 6
-Vstab 7
47 µF +

C1 R1
-VS 8
510Ω

Oscillator

Stabilization Power-on reset Load dump detection
1 GND

VBatt

Rear Window Heating Timer/ Long-term Timer

U6046B
4 OFF
5 TOGGLE

Frequency divider

Debouncing

Mono flop

Relay control 2
output

Pin Configuration

Figure Pinning

GND 1 OUT 2

ON 3 OFF 4
8 VS 7 VSTAB 6 OSC 5 TOGGLE

Table

Pin Description Pin 1 2 3 4 5 6 7 8

Symbol GND OUT ON OFF

TOGGLE OSC VSTAB VS

Function Reference point, ground Relay control output Switch-on input Switch-off input Toggle input RC-oscillator input Stabilized voltage Supply voltage
2 U6046B

U6046B

Functional Description

Power Supply Pin 8

For reasons of interference protection and surge immunity, the supply voltage pin 8 must be provided with an RC circuit as shown in Figure Dropper resistor, R1, limits the current in case of overvoltage, whereas C1 smooths the supply voltage at pin

Recommended values are R1 = 510Ω, C1 = 47 µF.

The integrated Z-diode 14V protects the supply voltage, VS. Therefore, the operation of the IC is possible between 6V and 16V, supplied by VBatt.

However, it is possible to operate the integrated circuit with a 5V supply, but it should be free of interference voltages. In this case, pin 7 is connected to pin 8 as shown in Figure 3-2 on page 3, and the R1C1 circuit is omitted.
Ordering Information

Extended Type Number U6046B-MY U6046B-MFPY U6046B-MFPG3Y

Package Information

Package DIP8 SO8

Package DIP8 Dimensions in mm
max.

Remarks Pb-free Tubed, Pb-free Taped and reeled, Pb-free

U6046B
nom. B
3 x = nom.
max.

Drawing-No. Issue 1;
technical drawings according to DIN specifications

Package SO 8 Dimensions in mm

Drawing-No. Issue 1;
technical drawings according to DIN specifications
14 U6046B

U6046B

History
4674B-AUTO-09/05
• Put datasheet in a new template
• Pb-free Logo on page 1 added
• Heading Rows on Table “Absolute Maximum Ratings” on page 9 added
• Table “Ordering Information” on page 14 changed

Atmel Corporation
2325 Orchard Parkway San Jose, CA 95131, USA Tel 1 408 441-0311 Fax 1 408 487-2600

Regional Headquarters

Europe Atmel Sarl Route des Arsenaux 41 Case Postale 80 CH-1705 Fribourg Switzerland Tel 41 26-426-5555 Fax 41 26-426-5500

Asia Room 1219 Chinachem Golden Plaza 77 Mody Road Tsimshatsui East Kowloon Hong Kong Tel 852 2721-9778 Fax 852 2722-1369

Japan 9F, Tonetsu Shinkawa Bldg. 1-24-8 Shinkawa Chuo-ku, Tokyo 104-0033 Japan Tel 81 3-3523-3551 Fax 81 3-3523-7581

Atmel Operations

Memory 2325 Orchard Parkway San Jose, CA 95131, USA Tel 1 408 441-0311 Fax 1 408 436-4314

Microcontrollers 2325 Orchard Parkway San Jose, CA 95131, USA Tel 1 408 441-0311 Fax 1 408 436-4314

La Chantrerie BP 70602 44306 Nantes Cedex 3, France Tel 33 2-40-18-18-18 Fax 33 2-40-18-19-60

ASIC/ASSP/Smart Cards Zone Industrielle 13106 Rousset Cedex, France Tel 33 4-42-53-60-00 Fax 33 4-42-53-60-01
1150 East Cheyenne Mtn. Blvd. Colorado Springs, CO 80906, USA Tel 1 719 576-3300 Fax 1 719 540-1759

Scottish Enterprise Technology Park Maxwell Building East Kilbride G75 0QR, Scotland Tel 44 1355-803-000 Fax 44 1355-242-743

RF/Automotive Theresienstrasse 2 Postfach 3535 74025 Heilbronn, Germany Tel 49 71-31-67-0 Fax 49 71-31-67-2340 1150 East Cheyenne Mtn. Blvd. Colorado Springs, CO 80906, USA Tel 1 719 576-3300 Fax 1 719 540-1759

Biometrics/Imaging/Hi-Rel MPU/ High Speed Converters/RF Datacom

Avenue de Rochepleine BP 123 38521 Saint-Egreve Cedex, France Tel 33 4-76-58-30-00 Fax 33 4-76-58-34-80

Literature Requests

Disclaimer The information in this document is provided in connection with Atmel products. No license, express or implied, by estoppel or otherwise, to any intellectual property right is granted by this document or in connection with the sale of Atmel products. EXCEPT AS SET FORTH IN ATMEL’S TERMS AND CONDITIONS OF SALE LOCATED ON ATMEL’S WEB SITE, ATMEL ASSUMES NO LIABILITY WHATSOEVER AND DISCLAIMS ANY EXPRESS, IMPLIED OR STATUTORY WARRANTY RELATING TO ITS PRODUCTS INCLUDING, BUT NOT LIMITED TO, THE IMPLIED WARRANTY OF MERCHANTABILITY, FITNESS FOR A PARTICULAR PURPOSE, OR NON-INFRINGEMENT. IN NO EVENT SHALL ATMEL BE LIABLE FOR ANY DIRECT, INDIRECT, CONSEQUENTIAL, PUNITIVE, SPECIAL OR INCIDENTAL DAMAGES INCLUDING, WITHOUT LIMITATION, DAMAGES FOR LOSS OF PROFITS, BUSINESS INTERRUPTION, OR LOSS OF INFORMATION ARISING OUT OF THE USE OR INABILITY TO USE THIS DOCUMENT, EVEN IF ATMEL HAS BEEN ADVISED OF THE POSSIBILITY OF SUCH DAMAGES. Atmel makes no representations or warranties with respect to the accuracy or completeness of the contents of this document and reserves the right to make changes to specifications and product descriptions at any time without notice. Atmel does not make any commitment to update the information contained herein. Unless specifically provided otherwise, Atmel products are not suitable for, and shall not be used in, automotive applications. Atmel’s products are not intended, authorized, or warranted for use as components in applications intended to support or sustain life.

Atmel Corporation All rights reserved. logo and combinations thereof, Everywhere You and others, are registered trademarks or trademarks of Atmel Corporation or its subsidiaries. Other terms and product names may be trademarks of others.

Printed on recycled paper.

More datasheets: ED06E5 | ED06F5 | ED10D5 | ED10B5 | ED10F5 | ED10E5 | AQD-D3L16R16-SM | T0797-6CP | U6046B-MFPG3Y | U6046B-MFPY

Notice: we do not provide any warranties that information, datasheets, application notes, circuit diagrams, or software stored on this website are up-to-date or error free. The archived U6046B-MY Datasheet file may be downloaded here without warranties.

Datasheet ID: U6046B-MY 519508